Product ID:ROYCO 770,TYPE 1
MSDS Date:07/22/1988
FSC:9150
NIIN:01-158-0462
MSDS Number: BSFKP

ROYAL LUBRICANTS CO INC

MERRY LANE
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411/800-424-9300(CHEMTREC)

Info Phone: 201-887-7410

Cage: 6V632

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

SYNTHETIC HYDROCARBON BASE OIL

CAS: 68649-12-7

Fraction By Weight: 60 - 65%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

SYNTHETIC ESTERS

Fraction By Weight: 25 - 30%

BARIUM DINONYLNAPHTALNE SULFONATE

CAS: 25619-56-1

Fraction By Weight: 2 - 3%

OSHA PEL 0.5 MG/M3 (AS BA)

ACGIH TLV: 0.5 MG/M3 (AS BA)

PHOSPHORIC ACID,TRITOLYL ESTER/TRICRESYL PHOSPHATE

CAS: 1330-78-5

RTECS: TD0175000

Fraction By Weight: 1 - 2%

MINOR ADDITIVES

Fraction By Weight: <2%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE- EYE CONTACT CAN CAUSE
IRRITATION. PROLONGED/REPEATED SKIN CONTACT MAY CAUSE DERMATITIS,
FOLLICULITIS/OIL ACNE. INJECTION OF OIL INTO SKIN MAY CAUSE LOCAL
NECROSIS. INHALATION OF VAPORS/OIL MIST MAY BE MILDLY IRRITATING
TO UPPER RESPIRATORY TRACT. HARMFUL IF INGESTED. CHRONIC-
DERMATITIS. TARGET ORGANS:SKIN.
Effects of Overexposure:EYES, SKIN, RESPIRATORY TRACT IRRITATION,
PERIPHERAL NERVE DAMAGE EVIDENCED BY MUSCULAR WEAKNESS AND LOSS OF
SENSATION IN ARMS AND LEGS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WIPE EXCESS. WASH SKIN WITH
SOAP & WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NEEDED. ORAL:IF CONSCIOUS, DRINK 2 GLASSES OF WATER & INDUCE
VOMITING. CALL A PHYSICIAN IMMEDIATELY. KEEP HEAD BELOW HIPS WHILE
VOMITING.

Flash Point:430F,221C
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CO2. DO NOT
USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS OPERATED IN+PRESSURE.
COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:TOXIC PHOSPHORUS OXIDES MAY BE FORMED.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. STOP LEAK. DIKE
SPILLS. USE PUMP TO TRANSFER SPILLS TO CONTAINER FOR DISPOSAL.
REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH
& SHOVELD INTO CONTAINE RS. PREVENT RUN-OFF TO ENTER WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM EXCESSIVE HEAT, FLAMES & STRONG OXIDIZERS.
Other Precautions:AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID
INHALING MISTS. EMPTY CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS
DUE TO THE RETENTION OF RESIDUES.

Respiratory Protection:NONE. IF TLV EXCEED, WEAR A NIOSH-APPROVED SELF
CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST FAN IS RECOMMENDED TO MAINTAIN CONCENTRATION
OF OIL MIST IN AIR BELOW RECOMMENDED TLV.
Protective Gloves:RUBBER/OIL RESISTANT GLOVES RECOMMENDED
Eye Protection:SAFETY GOGGLES/FACE SHIELD IF NEEDED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NOTE TO PHYSICIAN:IF VICTIM IS A CHILD, GIVE 1 GLASS OF WATER & 15 CC
(1 TABLESPOON) SYRUP OF IPECAC. IF SYMPTOMS SUCH AS LOSS OF GAG
REFLEX, CONVULSIONS/UNCONSCIOUSNESS OCCUR BEFORE EMESIS, GASTRIC L
AVAGE FOLLOWING INTUBATION WITH A CUFFED ENDOTRACHEAL TUBE SHOULD
BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:0.86
Solubility in Water:NEGLIGIBLE
Appearance and Odor:AMBER OIL - SLIGHT ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH HEAT, FLAMES
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES (CARBON MONOXIDE & OTHER UNIDENTIFIED
CMPD.)

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. THIS
PRODUCT IS AN OIL. SPILLS INTO OR LEADING TO SURFACE WATERS THAT
CAUSE A SHEEN MUST BE REPO RTED TO THE NRC, 800-424-8802.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.